Characterization of DEF affected concretes: detection and modification of properties
DOI:
https://doi.org/10.3989/mc.2022.17321Keywords:
Delayed ettringite formation (DEF), Durability indicators, Detection, Monitoring, SwellingAbstract
The evolutions of the different physicochemical and mechanical properties as a function of the expansion due to Delayed Ettringite Formation (DEF) in concrete are studied. In comparison of sound materials, some characterizations were made in accordance to the level of expansion: in the initial time, in the latent period, in the accelerating phase and at the end of expansion. The characterization was as follows; SEM analysis was used to observe the presence of DEF. Physical tests linked to transfer properties; gas permeability and electrical resistivity were measured to detect micro-cracks generated by the DEF advancement. To observe the impact of micro-cracks, compressive strength and static modulus were experimentally determined. It was observed that few tests can be used to detect theses pathologies earlier, during the latent period. Gas permeability, electrical resistivity and elastic modulus results were promising. These tests are very sensitive to the development of micro-cracks generated in the concrete by the development of swelling due to DEF.
Downloads
References
Brunetaud, X. (2005) Étude de l'influence de différents paramètres et de leurs interactions sur la cinétique et l'amplitude de la réaction sulfatique interne au béton. PhD thesis, École Centrale de Paris (http://www.theses.fr/2005ECAP1025).
Scherer, G. (1999) Crystallization in pores. Cem. Conc. Res. 29, 1347-1358. https://doi.org/10.1016/S0008-8846(99)00002-2
Mehta, P.K. (1973) Mechanism of expansion associated with ettringite formation. Cem. Conc. Res. 3, 1-6. https://doi.org/10.1016/0008-8846(73)90056-2
Scrivener, K.L.; Taylor, H.F.W. (1993). Delayed ettringite formation: a microstructural and microanalytical study. Adv. Cem. Res. 5 [20], 139-146. https://doi.org/10.1680/adcr.1993.5.20.139
Diamond, S. (1996) Delayed ettringite formation - Processes and problems. Cem. Conc. Comp. 18, 205-215. https://doi.org/10.1016/0958-9465(96)00017-0
Li, G.; Le Bescop, P.; Moranville, M. (1995) Expansion mechanism associated with the secondary formation of the U phase in cement-based systems containing high amounts of Na2SO4. Cem. Conc. Res. 26 [2], 195-201. https://doi.org/10.1016/0008-8846(95)00199-9
Zhang, Z.; Olek, J.; Diamond, S. (2002) Studies on delayed ettringite formation in heat-cured mortars II. Characteristics of cement that may be susceptible to DEF. Cem. Conc. Res. 17, 1737-1742. https://doi.org/10.1016/S0008-8846(02)00894-3
Leklou, N. (2008) Contribution à la connaissance de la réaction sulfatique interne, PhD thesis, Université Toulouse III.
Fu, Y.; Ding, J.; Beaudoin, J.J. (1997) Expansion of Portland cement mortar due to internal sulfate attack. Cem. Conc. Res. 27, 1299-1306. https://doi.org/10.1016/S0008-8846(97)00133-6
Kchakech, B. (2016) Étude de l'influence de l'échauffement subi par un béton sur le risque d'expansions associées à la réaction sulfatique interne. PhD thesis Université Paris-Est.
Graf, L. (2007) Effect of relative humidity on expansion and microstructure of heat-Cured mortars. RD139, Portland Cement Association, Skokie, Illinois, USA, (2007).
Al Shamaa, M. (2012) Étude du risque de développement d'une réaction sulfatique interne et de ses conséquences dans les bétons de structure des ouvrages nucléaires. PhD thesis, Université Paris-Est.
Jabbour, J. (2018) Méthodes d'essais de vieillissement accéléré des bétons à l'échelle des ouvrages. PhD thesis, Université Paris-Saclay.
NF EN 197-1 (2012). Ciment - Partie 1: Composition, spécifications et critères de conformité des ciments courants, AFNOR, (2012).
ODOBA project (2018) by IRSN https://www.irsn.fr/EN/Research/Research-organisation/Research-programmes/Odoba-project/Pages/ODOBA.aspx.
NF P18-404 (1981) Bétons - Essais d›étude, de convenance et de contrôle - Confection et conservation des éprouvettes, AFNOR (1981).
NF P18-400 (1981) Bétons - Moules pour éprouvettes cylindriques et prismatiques, AFNOR (1981).
Méthode d'essai n°66 (2007). Réactivité d'un béton vis-à-vis d'une réaction sulfatique interne. Laboratoire Central des Ponts et Chaussées (2007).
Leklou, N.; Aubert, J-E. ; Escadeillas, G. (2013) Influence of various parameters on heat-induced internal sulphate attack. Europ. J. Env. Civ. Eng. 17, 141-153. https://doi.org/10.1080/19648189.2012.755338
PerfDuB (2017) Determination of the resistivity of saturated concrete. IREX (2017).
XP P18-463, 2011. Bétons - Essai de perméabilité aux gaz sur béton durci, AFNOR (2011).
NF EN 12390-3 (2003) Essais pour béton durci - Partie 3: Résistance à la compression des éprouvettes, AFNOR, (2003).
NF EN 12390-13 (2014) Essai pour béton durci - Partie 13: détermination du module sécant d'élasticité en compression, AFNOR (2014).
Al Shamaa, M.; Lavaud, S.; Divet, L.; Colliat, J-B.; Nahas, G.; Torrenti, J.-M. (2016) Influence of limestone filler and of the size of the aggregates on DEF. Cem. Conc. Comp. 71, 175-180. https://doi.org/10.1016/j.cemconcomp.2016.05.007
Grattan-Bellew, P.E.; Beaudoin, J.J.; Vallée, V-G. (1998) Effect of aggregate particle size and composition on expansion of mortar bars due to delayed ettringite formation. Cem. Conc. Res. 28 [8], 1147-1156. https://doi.org/10.1016/S0008-8846(98)00084-2
Bentz, D.P.; Ardani, A.; Barrett, T.; Jones, S.Z.; Lootens, D.; Peltz, M.A.; Sato, T.; Stutzman, P.E.; Tanesi, J.; Weiss, W.J. (2015) Multi-scale investigation of the performance of limestone in concrete. Cons. Build. Mat. 75, 1-10. https://doi.org/10.1016/j.conbuildmat.2014.10.042
Yang, R.; Lawrence, C.D.; Sharp, J.H. (1999) Effect of type of aggregate on delayed ettringite formation. Adv. Cem. Res. 11 [3], 119-132. https://doi.org/10.1680/adcr.1999.11.3.119
Bouzabata, H.; Multon, S.; Sellier, A.; Houari, H. (2012) Effects of restraint on expansion due to delayed ettringite formation. Cem. Concr. Res. 42, 1024-1031. https://doi.org/10.1016/j.cemconres.2012.04.001
Al Shamaa, M.; Lavaud, S.; Divet, L.; Nahas, G.; Torrenti, J.M. (2015) Influence of relative humidity on delayed ettringite formation. Cem. Concr. Comp. 58, 14-22. https://doi.org/10.1016/j.cemconcomp.2014.12.013
Bruneteaud, X.; Divet, L.; Damidot, D. (2008) Impact of unrestrained Delayed Ettringite Formation-induced expansion on concrete mechanical properties. Cem. Conc. Res. 38, 1343-1348. https://doi.org/10.1016/j.cemconres.2008.05.005
Al Shamaa, M.; Lavaud, S.; Divet, L.; Nahas, G.: Torrenti, J.M. (2014) Coupling between mechanical and transfer properties and expansion due to DEF in a concrete of a nuclear power plant. Nucl. Eng. Desig. 266, 70-77. https://doi.org/10.1016/j.nucengdes.2013.10.014
Rivard, P.; Saint-Pierre, F. (2009) Assessing alkali-silica reaction damage to concrete with non-destructive methods: From the lab to the field. Cons. Buil. Mat. 23, 902-909. https://doi.org/10.1016/j.conbuildmat.2008.04.013
Martin, R-P.; Sanchez, L.; Fournier, B.; Toutlemonde, F. (2017) Evaluation of different techniques for the diagnosis & prognosis of Internal Swelling Reaction (ISR) mechanisms in concrete. Construct. Build. Mater. 156, 956-964. https://doi.org/10.1016/j.conbuildmat.2017.09.047
Published
How to Cite
Issue
Section
License
Copyright (c) 2022 Consejo Superior de Investigaciones Científicas (CSIC)

This work is licensed under a Creative Commons Attribution 4.0 International License.
© CSIC. Manuscripts published in both the print and online versions of this journal are the property of the Consejo Superior de Investigaciones Científicas, and quoting this source is a requirement for any partial or full reproduction.
All contents of this electronic edition, except where otherwise noted, are distributed under a Creative Commons Attribution 4.0 International (CC BY 4.0) licence. You may read the basic information and the legal text of the licence. The indication of the CC BY 4.0 licence must be expressly stated in this way when necessary.
Self-archiving in repositories, personal webpages or similar, of any version other than the final version of the work produced by the publisher, is not allowed.