Ceramic wastes as raw materials in portland cement clinker fabrication: characterization and alkaline activation

Authors

  • F. Puertas Instituto de Ciencias de la Construcción Eduardo Torroja (CSIC). Madrid
  • A. Barba Instituto de Tecnología Cerámica. Asociación de Investigación de las Industrias Cerámicas. Universitat Jaume I. Castellón
  • M. F. Gazulla Instituto de Tecnología Cerámica. Asociación de Investigación de las Industrias Cerámicas. Universitat Jaume I. Castellón
  • M. P. Gómez Instituto de Tecnología Cerámica. Asociación de Investigación de las Industrias Cerámicas. Universitat Jaume I. Castellón
  • M. Palacios Instituto de Ciencias de la Construcción Eduardo Torroja (CSIC). Madrid
  • S. Martínez-Ramírez Instituto de Ciencias de la Construcción Eduardo Torroja (CSIC). Madrid

DOI:

https://doi.org/10.3989/mc.2006.v56.i281.94

Keywords:

cement manufacture, ceramic waste, characterization, alkali activation, pozzolanicity

Abstract


The world-wide cement industry is seeking experimental avenues that will lead to cement production that is less energy-intensive, less damaging to the surrounding environment and less prolific in GHG emissions. In Spain and Europe in general, this approach is wholly consistent with the concept of sustainability and compliance with the Kyoto Protocol. The use of different kinds of industrial waste and by-products as alternative materials in cement manufacture has proved to be a very effective way of contributing to such sustainability. These alternative materials may be incorporated during cement production by partial/y replacing conventional fuel and/or the raw materials ground into the raw mix, or by including active additions to the cement and/or clinker.
The present paper discusses the preliminary results obtained in a study of the composition and alkali activation of six types of fired ceramic waste with a view to their viability as partial replacements for some of the prime materials used to prepare raw mix for Portland cement.
The results show that the chemical and mineralogical composition of the six materials makes them apt for such possible use. They are neither toxic nor radioactive. And as might be expected this type of waste exhibits pozzolanic activity. Alkali activation of the waste, low at the age analyzed (8 days), does not appear to be affected by the vitreous phase content or the nature of the activator. The characterization study conducted on the activated paste shows that the feldspar phases are the ones most susceptible to dissolution and reaction with the alkaline solutions.

Downloads

Download data is not yet available.

References

(1) F. Rougemont, «Sustainable development in the cement industry: The South African record». 11th ICCC, Durban, 2003, pp. 9-18.

(2) F. Puertas, M. T. Blanco-Varela, «Empleo de combustibles alternativos en la fabricación de cemento. Efecto en las características y propiedades de clínkeres y cementos», Mater. Construcc./ na 274 (2004), pp. 51-64.

(3) Norma UNE-ENV 197-1/2002.%,

(4) F. Puertas, M. T. Blanco-Varela, A. Palomo, T. Vázquez, «Reactivity and burnability of raw mixes made with crystallized blastfurnace slag. Part 1», Zement Ka/k Gips/ 8 (1988) pp. 398-402.

(5) F. Puertas, M. T. Blanco-Varela, A. Palomo, T. Vázquez, «Reactivity and burnability of raw mixes made with crystallized blastfurnace slag. Part 1», Zement Ka/k Gips/ 12 (1988), pp. 628-631.

(6) F. Puertas, M. T. Blanco-Varela, A. Palomo, T. Vázquez, «Reactividad y aptitud a la cocción de crudos de cemento que contienen escorias cristalizadas de horno alto», Cemento y Hormigón/ 854 (2003), pp. 4-10.

(7) A. Monshi, M. Kasiri, «Producing portland cement from iron and steel slags and limestone», Cem. Concr. Res. Vol. 29 (1999), pp. 1373-1377. doi:10.1016/S0008-8846(99)00028-9

(8) H. Hirao, S. Yokohama, «Behaviour of chloride ions in hardened ecoment: New type of Pórtland cement made from municipal waste incinerator ash». 11th ICCC, Durban (2003), pp. 1271-1281.

(9) P. H. Shih, J. E. Chang, L. C. Chiang, «Replacement of raw mix in cement production by municipal solid waste incineration ash», Cem. Concr. Res./ Vol. 23 (2003), pp.1831-1836.' doi:10.1016/S0008-8846(03)00206-0

(10) S. Goñi, A. Guerrero, M. A. Macías, R. Peña, E. Fernández-Escalante, «Empleo de materiales secundarios como materia prima de nuevos tipos de cementos», Mater. Construcc. nº 263-254 (2001), pp. 71-84.

(11) M. T. Blanco-Varela, T. Vázquez, A. Palomo, «Utilización de cenizas volantes y mineralizadores como materia prima en la fabricación de cemento», Mater. Construcc. 188 (1983), pp. 45-53.

(12) M. T. Blanco-Varela, «Reactivity of fly-ashes when they are used as constituent of Portland cement raw mixes», TIZ-Fachberichte, 5 (1984), pp. 304-307.

(13) M. T. Blanco-Varela, F. Puertas, A. Palomo, T. Vázquez, P. Artola, I. Alfaro, «Aptitud a la cocción de crudos de cemento Pórtland usando PavaI como materia prima», Cemento y Hormigón, 809 (2000), pp. 358-377.

(14) F. Puertas, M. T. Blanco-Varela, T. Vázquez, «Behaviour of cement mortars containing an industrial waste from aluminium refining. Stability in Ca(OH)2 solutions», Cem. Concr. Res. Vol. 29 (1999), pp. 1673-1680. doi:10.1016/S0008-8846(99)00157-X

(15) M. Singh, S. N. Upadhayay, P.M. Prasad, «Preparation of special cements from red mud», Waste Managemen~ 16 (1996), pp. 665-670. doi:10.1016/S0956-053X(97)00004-4

(16) A. Diouri, A. Boukhari, J. Aride, F. Puertas, T. Vázquez, «Stable Ca2Si03 solid solutio containing manganeso and phosphorus», Cem.'•",Concr. Res., Vol. 27 (1997), pp. 1203-1212. doi:10.1016/S0008-8846(97)00110-5

(17) A. Diouri, A. Boukhari, J. Aride, F. Puertas, T. Vázquez, «Elaboración de un clínker belítico fosfático con L-C2S- Estudio de su actividad hidráulica», Mater: Construcc., 249 (1998), pp. 23-32.

(18) M. Singh, M. Garg, «Making of anhydrite cement from waste gypsum», Cem. Concr: Res., Vol. 30 (2000), pp. 571-577. doi:10.1016/S0008-8846(00)00209-X

(19) A. Hauser, U. Eggenberger, T, Mumenthaler, «Fly ash from cellulose industry as secondary raw material in autoclaved aerated concrete», Cem. Concr: Res., Vol. 29 (1999), pp. 297-302. doi:10.1016/S0008-8846(98)00207-5

(20) J. E. Enrique, E. Monfort, «Situación actual y perspectivas de futuro de los residuos de la industria azulejera», Cerámica información, 221 (1996), pp. 20-34.

(21) J. E. Enrique, E. Monfort, G. Busani et al., Tratamiento de emisiones gaseosa~ efluentes líquidos y residuos sólidos de la industria cerámica, Instituto de Tecnología Cerámica-AlCE, Castellón, 1992.

(22) E. Monfort, J. E. Enrique, M. F. Gazulla et al., «Caracterización de residuos de la industria azulejera», Técnica Cerámica, 222 (1994), pp. 238-246.

(23) E. Criado, E. Sánchez, M. Regueiro, «AII tiled up: Spanish ceramics and glass», Ind. Miner:, 444 (2004), pp. 48-55.

(24) E. Criado, E. Sánchez, M. Regueiro, «La industria cerámica española, ¿ante un cambio de ciclo?», Bol. Soco Esp. Ceram. Vidr:, 43 (2004), pp. 85-10l.

(25) E. Monfort, M. Monzo, J. C. Jarque et al., «Recycling red-fired tile scrap in red-firing floor and wall tile compositions», Tile Brick Int., 16 (2000), pp. 420-427.

(26) E. Monfort, M. Monzo, J. C. Jarque et al., «Reciclado de tiesto en composiciones de pavimento y revestimiento rojo (1) », Técnica Cerámica, 292 (2001), pp. 450-458.

(27) E. Monfort, M. Monzo, J. C. Jarque et al., «Reciclado de tiesto en composiciones de pavimento y revestimiento rojo (11) », Técnica Cerámica, 293 (2001), pp. 629-633.

(28) J. E. Enrique, E. Monfort, J. V. Agramunt et al., «Gestión de vertidos en la fabricación de baldosas cerámicas», Técnica Cerámica, 246 (1996), pp. 478-485.

(29) M. H. Young, K. K. Hyng, «A research on the recycling of ceramic wastes as an aggregate for concrete», Chawon Rissaikuring, 10 (2001), pp. 41-49.

(30) M. 1. Sánchez-Rojas, M. Frías, J. Rivera et al., «Waste products from prefabricated ceramic materials as pozzolanic addition». 11th ICCC, Durban, 2003, pp. 935-943.

(31) M. 1. Sánchez-Rojas, M. Frías, J. Rivera, «Study on the pozzolanic and calorimetric behaviour of industrial products and wastes for use as calcined natural pozzolans in the manufacture of portlandcement CEM/A and B-Q», Cemento y Hormigón, 837 (2002), pp. 12-21.

(32) Ay N, Ü. M., «The use of waste ceramic tile in cement production», Cem. Concr: Res., Vol. 30 (2000), pp. 497-499. doi:10.1016/S0008-8846(00)00202-7

(33) A. Barba, M. F. Gazulla, M. P. Gómez et al., «Chemical characterization of geological raw materials used in traditional ceramics», Geostandards and Geoanalytical Research, 28 (2004), pp. 203-212. doi:10.1111/j.1751-908X.2004.tb00737.x

(34) A. Barba, M. F. Gazulla, M. P. Gómez et al., «A methodology for characterizing ceramic wastes: management of Environmental Quality», An International Journal, 14 (2003), pp. 333-343.

(35) A. Barba, M.F. Gazulla, M.P. Gómez et al., «Preparation of reference materials for frit chemical analysis», Glastech. Ber.-Glass Sci Technol, 75 (2002), pp. 184-190.

(36) A. Barba, M. F. Gazulla, M. P. Gómez et al., «Characterization of chromium-containing ceramic pigments by XRF and XRD», X-ray Spectrometry, 33 (2004), pp. 431-438. doi:10.1002/xrs.745

(37) A. Barba, M. F. Gazulla, M. P. Gómez et al., «Characterisation of ceramic oxide refractories by XRF and XRD», X-ray Spectrometry, 33 (2004), pp. 421-430. doi:10.1002/xrs.743

(38) A. Barba, M. F. Gazulla, M. P. Gómez et al., «Physico-chemical characterisation of silicon carbide refractories», J. Europ. Ceram Soc., (in press).

(39) A. Barba, S. Maestre, E. Bou. et al., «Using the hot stage microscope for estimating frit sealing temperature», Cfi (Ceramic Forum International)/Ber: DKG, 78 (2001), E36-E39.

(40) Orden Ministerial del 13 de octubre de 1989, apéndice IV (BOE nº 270, de 10 de noviembre de 1989).

(41) UNE-EN ISO 11348.

(42) Documento de la Unión Europea: «RPl12 Radiological protection principies concerning the natural radioactivity of building materials».

(43) EN 196-5, «Métodos de ensayos de cementos. Ensayo de puzolanicidad para cementos puzolánicos».

(44) M. 1. Sánchez de Rojas, M. Frías, J. Rivera et al., «Investigación sobre la reactividad puzolánica de materiales de desecho procedentes de arcilla cocida», Mater. Construcc., 262 (2001).

(45) A. Palomo, A. Fernández-Jiménez, M. Criado, «Geopolímeros: Una única base química y diferentes microestructuras», Mater. Construcc., 275 (2004), pp. 77-9l.

(46) A. Fernández-Jiménez, J. G. Palomo, F. Puertas, «Alkali-activated slag mortars: mechanical strength behaviour», Cem. Concr. Res., Vol. 29 (1999), pp. 1313-132l. doi:10.1016/S0008-8846(99)00154-4

(47) H. W. van der Marel, H. Beutelspacher, Atlas of Infrared spectroscopy of c1ay minerals and their admixtures, Ed Elsevier, 1976.

(48) G. Engelhardt, D. Michel, High resolution solid-state ofsilicates and zeolites, Ed. John Wiley and Sons, 1987.

Downloads

Published

2006-03-30

How to Cite

Puertas, F., Barba, A., Gazulla, M. F., Gómez, M. P., Palacios, M., & Martínez-Ramírez, S. (2006). Ceramic wastes as raw materials in portland cement clinker fabrication: characterization and alkaline activation. Materiales De Construcción, 56(281), 73–84. https://doi.org/10.3989/mc.2006.v56.i281.94

Issue

Section

Research Articles

Most read articles by the same author(s)

<< < 1 2 3 4 5 6 7 > >>